Modern microprocessors

Robust, high-performance aerospace and defense systems harness the power of innovative microprocessors.

BY Courtney E. Howard

Aerospace and defense professionals, in the quest to do more with less, have turned their attentions to infusing systems new and old with robust, capable, efficient microprocessors. A wealth of high-performance computing options exist, however, causing systems architects and systems integrators to consider closely all options when selecting silicon.

A set of characteristics is fairly common across most aerospace and defense applications, whether an airborne platform, tactical radio, radar, or munition; yet, the value, or priority, of these characteristics can vary significantly depending on the application, explains Jason Moore, director of aerospace and defense applications engineering at Xilinx Inc. in San Jose, Calif., which specializes in field-programmable gate arrays (FPGAs).

Performance-including throughput, interrupt latency, and cache size and speeds-is an important consideration, as is the board support package (BSP) for real-time operating systems (RTOSs) and device drivers (e.g., a DO-178B RTOS for avionics applications), Moore says. Memory and I/O interfaces, cost, and anti-tamper and physical security characteristics should also be considered.

BAE Systems 3U and 6U boards sport the company's radiation-hardened processors, which are employed on a variety of satellites.

"It is important to differentiate between dynamic power and static power when considering power consumption," Moore adds. "Dynamic power is a serious consideration in high-performance systems, such as large radar arrays, where there are concerns with how to get the heat out/cool the system. Static power and sleep modes are also critical in military communications, like tactical radios, where battery life is critical.

"Maintaining the integrity of the data, through the use of technology, such as error-correcting code (ECC) or processor lockstep operation, throughout the processing subsystem is important across many applications, such as avionics and military communications," Moore advises.

COTS computing

Microprocessors for aerospace and defense applications are following the same vector as those used in the broader commercial market, recognizes Rod Rice, general manager of Military & Aerospace Products at GE Intelligent Platforms in Charlottesville, Va. The proliferation of commercial off-the-shelf (COTS) solutions which leverage commercial technologies reduce cost and development time, while increasing performance and providing regular technology insertion opportunities, long-term support roadmaps, and overall lower cost of ownership, he says.

"The impact of this can be clearly seen in the offerings from companies like Intel," Rice says, recalling that the second generation of Intel Core processors was announced roughly one year ago. "The next generation will be with us shortly with, it is reported, a smaller die size and an increased number of transistors that will provide another uptick in performance. These will be incorporated into mil-aero board level products in the coming months."

Mil-aero applications are increasingly favoring multi-core microprocessors, allowing for greater processing capacity, Rice adds. "As well as Intel's multi-core offerings, Freescale-the other significant microprocessor supplier to the mil- aero market-provides solutions, such as the QoriQ P4080 with its eight processors."

The ability to use several processors within one piece of silicon has given rise to the growing adoption of technologies that use massively parallel architectures, including graphics processing unit (GPU) technology, such as CUDA from Nvidia in Palo Alto, Calif., Rice observes. General-purpose computing using GPGPUs (general-purpose GPUs) is enabling significant performance increases in mil-aero applications that can leverage that parallelism, such as radar, in which increased throughput on the order of 15X has been demonstrated in comparison with more traditional processor approaches, he says.

"Another key requirement, given the space constraints under which many mil-aero programs are deployed, is a higher degree of silicon integration that allows for either smaller form factor (SFF) boards or higher functional density on a single board," Rice says. Integration of graphics capability, for example, within the processor is highly desirable; moreover, he adds, as mil- aero applications become increasingly graphics-intensive, focus is on the quality of integrated graphics.

Increased imagery

Kevin Berce, defense manager at Nvidia, is seeing a dramatic increase in demand for Nvidia Tesla GPUs in the defense market. Three application areas, in particular, are growing the fastest: image processing, signal processing, and data analytics. "MotionDSP is a great example of the benefit of GPU acceleration in the image processing space," he says.

MotionDSP's Ikena ISR product uses algorithms to enhance video with cleaner detail, increased resolution, and reduced noise, making it well suited for real-time streaming of high-quality video from unmanned aerial vehicle (UAV) sensors. By harnessing Nvidia Tesla GPUs, the software can process 30 frames per second, with less than 300 milliseconds latency. Improved image quality and streaming performance enable the Department of Defense to access more accurate and actionable information quickly.

Each of these applications "requires significant processing power that cannot be achieved easily or cost-effectively with CPU-only systems," Berce says. "In some cases, CPUs simply cannot provide enough processing power to process the data fast enough to deliver actionable information or intelligence." For example, to process a single hour of UAV video with Ikena ISR typically takes four to six hours on a CPU-based system; yet, a hybrid system combining a CPU and GPU can process the same hour of video in real time.

"Due to the highly parallel architecture of GPUs, they can provide an order of magnitude greater performance than CPUs, and can easily accelerate applications to give the military invaluable data immediately," Berce notes.

The benefits of GPUs go beyond application acceleration, extending to space, power, and cost savings. "GPUs allow government customers to save money on compute resources, without compromising on performance," Berce explains. Solers Inc., a provider of information technology solutions to government customers, was able to eliminate 20 blades (from 68 to 48) by adding six GPUs to its Dell server. By introducing GPUs into its Dell system, Solers reduced the footprint by 30 percent and power consumption by 27 percent, while delivering greater performance by reducing processing latency by 25 percent, he says.

Nvidia's GPUs are actively being adopted in aerospace and defense data centers as well as in electronics systems on the battlefield. Its Tesla brand GPUs are designed to meet computational requirements in data centers and high-performance computing environments, as well as to deliver performance increases for a variety of applications, including computational fluid dynamics, video processing, synthetic aperture radar (SAR), and electromagnetics. "GPUs are being deployed by key computer original equipment manufacturers (OEMs) and partners offering embedded solutions, such as GE Intelligent Platforms and Curtiss-Wright.

Microprocessors, and GPUs specifically, have a bright future in the mil-aero arena, Berce adds. "GPUs will continue to improve the performance per watt, outpacing the advantages of a CPU-only system. As a result, GPUs will drive a new generation of applications that deliver better, more accurate information quickly with much higher fidelity."

Military vs. COTS

The requirements for aerospace and defense microprocessors differ somewhat from their commercial counterparts in key areas, says Rice. "The provision of a floating-point processor-AVX in Intel's case, and AltiVec from Freescale-is important for demanding digital signal processing (DSP) applications.

"As significant processing power is increasingly deployed within environments that are highly space- and power-constrained, low power consumption-with its associated reduced cooling requirement-is a key characteristic. Many mil-aero applications have begun to focus more on performance/watt rather than pure performance," Rice adds.

"The majority of mil-aero applications are deployed in harsh environments that are subject to shock, vibration, moisture, dust, and so on," Rice says. "While this does not place specific requirements on the processor itself, it must be capable of being integrated on a rugged board designed to withstand the rigors of military deployment.

"The typical mil-aero program can be deployed over years, and even decades. This generates a requirement for long-term availability of components and long-term support for those components, as well as a requirement for form/fit/function-compatible upgrades over time to allow for technology insertion, increasing performance while maximizing long-term cost of ownership," Rice continues. "While performance and low power consumption will always be key considerations for prime contractors and OEMs in choosing a single-board computer, the guarantee of long-term availability over an extended period is no less important."

Engineers at Harris Corp.'s Government Communications Systems Division (GCSD) in Melbourne, Fla., understand well the importance of long-term support and the provision of regular technology insertion opportunities. Harris officials first selected GE's PPC7E single-board computer in 1999 for the high-mobility artillery rocket system (HIMARS), the newest member of the multiple-launch rocket system (MLRS) family. More than a decade later, GE continues to provide the board.

GE Intelligent Platforms continues to secure Harris orders for PPC7EP single-board computers; the latest in a series of orders placed by Harris for the MLRS program over 12-plus years is a roughly $3.5 million order placed in Nov. 2011. Lockheed Martin engineers subcontracted Harris to design and build the electronics for the U.S. Army's MLRS M-270 HIMARS platform. The PPC7EP executive processor is a custom variant of GE's PPC7D, a 6U VME single-board computer featuring the 7448 PowerPC processor. Three PPC7EPs, one with a PMCGA4C graphics accelerator card, are deployed in each vehicle and provide computing power to the HIMARS subsystems.

"MLRS/HIMARS is an outstanding example of a long-term program that relies on the continuing availability of critical components, the extended support (such as obsolescence management) necessary to ensure success, and the opportunity for ongoing technology insertion," says Al DiLibero, president of Military & Aerospace Embedded Computing at GE Intelligent Platforms.

Computational communications

Just as microprocessors benefit from the power inherent in GPUs, they are likewise aided in aerospace and defense applications by robust field-programmable gate arrays (FPGAs). Xilinx integrated processors and embedded processing solutions are used in missiles and munitions, for target tracking; military communications, for black-side modem operations and red-side key management and user interface; and electronic warfare/intelligence, surveillance, and reconnaissance (EW/ISR), such as radar algorithm processing.

"Software-defined radio (SDR) platforms classically consist of a general-purpose processor (usually ARM) and FPGA for user interface and baseband signal processing respectively," Moore says. "Interest in Zynq for SDR is not just about integrating the classic SDR baseband functions to reduce size and power, it is also about increased system performance and decreased development effort."

The GE Intelligent Platforms PPC7D is a 6U VME single-board computer featuring the 7448 PowerPC processor.

The Zynq ARM cores are tightly coupled to peripherals (hardened I/O, DDR, and logic) by the AMBA AXI-4 interconnect fabric, which also connects the programmable logic (PL) to all these subsystems, Moore explains. "It is the AXI fabric that allows high-throughput, low-latency, standards-based interconnect of custom logic for modem, cryptographic, and other hardware-in-the-loop logic to the ARM cores, hardened I/O, and DDR. The advantage in lower development time and faster throughput over a separate ARM + FPGA devices is substantial."

Moore considers Zynq a paradigm shift for system on a chip (SoC) FPGA technology. "It allows higher levels of integration with a processor-centric, boot-first point of view that can reduce the SWAP-C (size, weight, power, and cost) of the system it is embedded in," he says. "Consider that the processing subsystem (PS) can be used stand-alone with the FPGA fabric completely powered off, if required. The processor is the master and is used to configure the PL. When performance is needed, the PL can be powered on and configured or reconfigured, either partially or fully, during system operation to the user application. The Zynq silicon platform, combined with the capabilities of AutoESL, Xilinx's High-Level Synthesis technology, blurs the lines between hardware and software."

Airborne application

A broad range of aerospace and defense applications and platforms require rugged microprocessors; this is especially true of airborne and land-based combat vehicles. "Kontron specializes in military environments that demand extreme ruggedization," says David O'Mara, product manager at Kontron in Poway, Calif. .

The Apache helicopter employs the company's COBALT with an onboard 8-port GigE switch, as well as an 80-gigabyte, solid-state drive and a Kontron Core2Duo single-board computer. COBALT is a small, lightweight computing device based on Kontron's COM Express single-board computer offering fanless operation and a Gigabit Ethernet interface.

Demand for optimized SWaP-C products is also growing, along with the UAV market. "The need for small, lightweight, fanless products will drive the development of microprocessors over the next several decades," O'Mara predicts. "Although SWaP-C and product life cycle are top priorities, numerous successes in the field are made possible by a solid computer health management and logistics support infrastructure."

Kontron is concentrating on power-on, built-in test (PBIT) and computer management board (CMB) innovations. "All these low level features, often hidden from the casual observer, make the difference in the end," O'Mara observes.

Kontron's COBALT small, lightweight computing device, based on Kontron's COM Express single-board computer, is employed on the Army AH-64 Apache attack helicopter.

Safe in space

Space, among the harshest environments for electronics, requires rugged, radiation-hardened processors. BAE Systems has, since the 1990s, been designing, building, and delivering radiation-hardened (rad-hard) processors via its rad-hard foundry in Manassas, Va., says Victor Scuderi, manager, Satellite Electronics, BAE Systems. "We develop the rad-hard processor chips, then design the single-board computer to use these processors."

The first-generation, single-board computer was a rad-hard version of a MIL-STD 1750 processor; followed by the RAD6000, a rad-hard version of an IBM RISC System 6000 processor. The current-generation RAD750, a rad-hard version of an IBM PowerPC 750 processor, is adopted for satellite single-board computers serving command and control functions and onboard payload processing. The Advanced Extremely High Frequency satellite, a U.S. Department of Defense (DOD) secured communications satellite, uses two RAD6000 computers for satellite control and eight RAD750 computers for the payload.

"One of the most critical factors for selecting a single-board computer for a space mission is 'flight heritage' measured in the number of hours, weeks, or years in space since the launch," Scuderi says. Satellite prime contractors demand flight heritage-demonstrated proof of the ability of a product to withstand the rigors of space-for five-year science missions or 15-year DOD/commercial missions. "There are currently 625 BAE Systems single-board computers used on 200+ satellites launched since 1995. We track every hour each of our computers has been in space. The three generations of BAE Systems computers have amassed an aggregate of 50,413,800 hours or 5,755 years in space."

Scuderi sees demand for very high-performance satellite payload processing solutions, the requirements of which also drive high-performance I/O and network capabilities. "This new market will require a collection of technology products, such as high-density FPGAs, DSPs, and multi-core, general-purpose processors. High-density ASICs will still be required to meet specialized functions and address power constraints," he says. "For each of these technology products, leveraging commercial intellectual property and enhancing it to meet the rigors of the space environment will continue to be a core element of our approach to meeting customer requirements."

Future functionality

The coming months, years, and decades will bring new applications and computing challenges requiring increasingly robust, efficient, and capable microprocessor technology.

"Microprocessors will become increasingly capable-not only delivering more throughput, but also integrating increased functionality-allowing for the greater functional density that will permit the deployment of highly sophisticated, demanding applications in smaller spaces," GE's Rice predicts. "There will continue to be focus on minimizing power consumption/heat dissipation. Multi-core processors will continue to gain market share, with the number of processors per piece of silicon increasing. The adoption of GPGPU technology will also continue."


Anemone co-processor

BittWare Anemone acceleration technology for FPGAs, available on an FMC (VITA 57) mezzanine card that attaches to BittWare's Altera-based FPGA COTS boards, offloads C language processing from an FPGA and is designed to help customers finish projects sooner, at lower risk and while consuming less power.

"The Anemone processor is a paradigm changer on many fronts; one of the most compelling is that it turns co-processing upside down by accelerating an FPGA instead of the other way around," says Jeff Milrod, BittWare president and chief executive officer.

The modularity of BittWare's Anemone floating-point co-processor for FPGAs enables its use on any of the company's carrier boards with an FMC connector.

Inside each Anemone104 (AN104) are 16 small and elegant RISC processors that are optimized for floating-point, interconnected, and tied directly into an FPGA. Anemone is an implementation of the Epiphany architecture from Adapteva, a startup company of which BittWare is an investor. The scalable "many core" processor has 16 eCores that run at rates up to 1 gigahertz, providing a total sustained performance of 32 GFLOPS while consuming two watts of total power. The AN104 features an internal, high-throughput, inter-core mesh network, with separate data paths for on-chip and off-chip communications.


OpenVPX module

Mercury Computer Systems has announced its Ensemble Series 6U OpenVPX HCD6210 rugged compute blade based on the Freescale T4240 QorIQ AMP Power Architecture. The HCD6210 blade uses two new Freescale T4240 processors and has a total of 24 cores/48 threads, each core with an Alti- Vec single-instruction, multiple-data (SIMD) engine for high-performance signal processing support. Systems based on the HCD6210 can scale from 1 to 16 boards, enabling new levels of subsystem performance in radar, electro-optical/infrared (EO/IR), and electronic warfare (EW) applications, says a representative.

"With the enormous budget pressures in the defense industry, more and more prime contractors are looking to upgrade existing systems with minimal change and cost. The HCD6210 compute blade provides a six-fold increase in processing capability while maintaining software library compatibility," explains Steve Patterson, vice president of product management at Mercury Computer Systems. "With its well-balanced computational performance and I/O capability, the performance is equally impressive for small, single-slot OpenVPX systems as it is for the large, scaled-up multi-board systems for which Mercury is known."

COMPANY INFO

AMD
http://www.amd.com
Apple
http://www.apple.com
ARM Inc.
http://www.arm.com
BAE Systems
http://www.baesystems.com
BittWare
http://www.bittware.com
Cavium Networks
http://www.cavium.com
Connect Tech
http://www.connecttech.com
Eurocom
http://www.eurocom.com
Freescale Semiconductor
http://www.freescale.com
Intel
http://www.intel.com
Mercury Computer
http://www.microsemi.com
Microsemi
http://www.microsemi.com
MIPS Technologies Inc.
http://www.mips.com
NEC
http://www.nec.com
Nvidia
http://www.nvidia.com
Texas Instruments
http://www.ti.com
VIA Technologies
http://www.via.com.tw
Zilog
http://www.zilog.com

More Military & Aerospace Electronics Current Issue Articles
More Military & Aerospace Electronics Archives Issue Articles


Easily post a comment below using your Linkedin, Twitter, Google or Facebook account.


The Innovation That Matters™ Quiz

Innovation is one of the key drivers in the Defense industry. View this short video of Leon Woo, VP of Engineering at Mercury Systems, on the role of innovation. Then, answer 3 simple questions correctly to be entered into a drawing to win an Eddie Bauer fleece jacket!

CONGRATULATIONS TO OUR TWO MOST RECENT WINNERS. "Nick from SPARWAR" and "Bridget from AOC."


Featured Slideshow

Evolution of the American soldier

The American soldier has come a long way since the beginning of the Republic 237 years ago. While uniforms for early soldiers were based on cost and utility, soldiers' clothing eventually considered ballistic protection, increasing storage space, protection from poison gas and other contaminants.

Related Products

RR2P Removable Canister RAID System

Transportable data storage for mobile field use aboard planes, ships and ground transport. 2U, du...

API DC Link Power Film Capacitors

High reliability DC link capacitors for power inverter applications which require superior life e...

XPort9200 Conduction- or Air-Cooled 12-Channel High-Speed CAN Bus XMC or PMC

The XPort9200 is a conduction- or air-cooled 12-channel CAN bus XMC or PMC module. Each high-spee...

Related Companies

Winchester Systems Inc

At its founding in 1981, Winchester Systems introduced its first 5 MB disk system for Intel development system users....

API Technologies Corp

Who We Are API Technologies is a dominant technology provider of RF/microwave, microelectronics, and security technol...

Extreme Engineering Solutions Inc (X-ES)

 Extreme Engineering Solutions, Inc. (X-ES) is a leader in the design, manufacture, and support of standard and ...
Wire News provided by   

Most Popular Articles

Webcasts

On Demand Webcasts

Engineering the VPX high-speed data path for physical and signal integrity

Join Arrow Electronics and TE Connectivity, for an overview webinar of the standards, technologies and trends involving VITA and TE.

Design Strategy Considerations for DO-178C Certified Multi-core Systems

Join Wind River to learn how system architecture and design choices can minimize your DO-178C certification challenges.

Sponsored by:

Flying, Sailing or Driving - The Rugged, Embedded Intel-based Server that goes where you need it!Flying Sailing or Driving

Leveraging the power of server-class processors is no longer relegated to the confines of data centers. Through several innovations, Mercury Systems has ruggedized Intel’s server-class chips for deployment. ...
Sponsored by:

social activity

All Access Sponsors


Mil & Aero Magazine

February 2014
Volume 25, Issue 2
file

Download Our Apps



iPhone

iPad

Android

Follow Us On...



Newsletters

Military & Aerospace Electronics

Weekly newsletter covering technical content, breaking news and product information
SUBSCRIBE

Defense Executive

Monthly newsletter covering business news and strategic insights for executive managers
SUBSCRIBE

Embedded Computing Report

Monthly newsletter covering news on embedded computing in aerospace, defense and industrial-rugged applications
SUBSCRIBE

Unmanned Vehicles

Monthly newsletter covering news updates for designers of unmanned vehicles
SUBSCRIBE